Nonessential Equipment and Furnishings (NEF) Manual

Nonessential Equipment and Furnishings (NEF) Manual

CESSNA Citation and Propeller Aircraft

(FAA Registered Aircraft)

Operator/Company:

Aircraft Model and Serial Number:

Registration Number:

COPYRIGHT © 2008
CESSNA AIRCRAFT COMPANY
WICHITA, KANSAS, USA / 1 MARCH 2008
CESNEF / ORIGINAL
Nonessential Equipment and Furnishings (NEF) / Cessna Aircraft Company
Citation and Propeller Aircraft

THIS LIST HAS NOT BEEN APPROVED BY THE FAA

ANY NEF LIST DEVELOPED BY THE OPERATOR MUST BE SUBMITTED TO THE FAA FOR REVIEW AND APPROVAL AS PART OF THEIR NEF PROGRAM, WHERE PROVIDED BY FAA PL-116 AND THE APPROPRIATE FAA GUIDANCE MATERIAL

ANY ITEM LISTED IN THE CURRENT AIRCRAFT MASTER MINIMUM EQUIPMENT LIST MAY NOT BE INCLUDED IN THE OPERATOR’S NEF PROGRAM

THIS LIST IS NOT ALL INCLUSIVE AND DOES NOT INCLUDE ALL ITEMS THAT MAY BE APPROPRIATE FOR DEFERRAL UNDER AN OPERATOR’S NEF PROGRAM

SOME ITEMS ON THE LIST MAY NOT BE APPROPRIATE FOR SOME OPERATOR’S NEF PROGRAMS

ALL INOPERATIVE ITEMS MUST BE PLACARDED IN ACCORDANCE WITH THE APPLICABLE OPERATING REGULATIONS

TABLE OF CONTENTS

Aircraft Compartment Area / Page No.
Flight Deck / 1
Cabin General / 4
Galley / 9
Passenger Compartment / 13
Lavatory / 15
Service Bays / 19
Baggage/Cargo / 21
Blank Page / 24

CESNEF1

Nonessential Equipment and Furnishings (NEF) / Cessna Aircraft Company
Citation and Propeller Aircraft
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
FLIGHT DECK
1Coat and/or Hat Hooks / May be missing or inoperative.
2Circuit Breaker Guards / (O) May be missing or inoperative.
OPERATIONAL PROCEDURE

Using zip-ties, secure the affected circuit breaker(s).
Make appropriate entry in discrepancy report.

3Cup Holders / May be missing or inoperative.
4Document Holder / (O) May be missing or inoperative.
OPERATIONAL PROCEDURE

Place required documents in a clear plastic bag.
Tape bag adjacent to document holder.
Make appropriate entry in discrepancy report.

5Eyebrow Window Visor / May be missing or inoperative.
6HGS Quilted Cover / May be missing or inoperative.
7Spring Clip (located left/right of document holder) / May be missing or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
FLIGHT DECK
8Seat Belt Tidy Clip / May be missing or inoperative.
9Spare Bulb Kit and Contents / May be missing or inoperative.
10Yoke Chart Clip(s) / May be missing or inoperative.
11Sunshades / May be missing or inoperative.
12Captain’s Briefcase Bungee / May be missing or inoperative.
13Carpet / May be missing, frayed or inoperative.
14Foot Tread Trim / May be missing, frayed or inoperative.
15Logbook Holder / May be missing or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
FLIGHT DECK
17Power Outlet / (M) May be missing or inoperative provided is secured.
MAINTENANCE PROCEDURE

Electrically isolate system from aircraft power supply.
Place an INOP placard on outlet.
Make appropriate entry in discrepancy report.

18Second Microphone Holder / May be missing or inoperative.
19Side Panel Door Cover / May be missing or inoperative.
20Spare Headset / May be missing or inoperative.
21Trim
(Seat, sidewall, overhead, etc.) / May be missing, frayed or inoperative.

CESNEF1

Nonessential Equipment and Furnishings (NEF) / Cessna Aircraft Company
Citation and Propeller Aircraft
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
CABIN GENERAL
1Appearance Items
(Cabin Interior Trim, Carpet/Floor Coverings, Curtains/Tiebacks, Wall Coverings – including sidewall panels; excluding sidewall return air grills) / May be missing, frayed or inoperative.
2Door Cover/Slide Bristle / May be missing, frayed, soiled, torn, damaged, loose or inoperative.
NOTE:Must not present a hazard to passengers/crew or impede emergency egress.
3Safety Demo Equipment
(Safety Belt, Life Vest, O2 Mask) / (O) May be missing or inoperative provided alternate procedures are established and used.
OPERATIONAL PROCEDURE

A member of the crew shall ensure all passengers are briefed on all applicable emergency procedures.
If inoperative, place an INOP placard on affected equipment.
Make appropriate entry in discrepancy report.

4Coat Hanger Installation / May be missing or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
CABIN GENERAL
5Cabin Lighting/Signs
(Reading lights, Light Lens/Covers)
NOTE:Only items not covered by MEL ATA 33. / May be missing loose, damaged or inoperative provided affected light functions normally.
6Spare Life Vest / May be missing or inoperative provided operating rules do not require its use.
7Magazine Rack/Restraint / May be missing or inoperative.
8Cabin Mirrors / May be missing damaged or inoperative.
9Seat Track Covers / May be missing or inoperative.
10Cabin Windows
(Interior Cosmetic Pane, Interior Panel, Shades and Window Trim) / May be crazed, damaged, soiled, loose, missing or inoperative.
NOTE:Any exposed wiring must be protected.
11PSU Panel / May be damaged or soiled provided it is properly functioning
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
CABIN GENERAL
12PSU Gasper Outlets / May be failed ON.
13Handheld Fire Extinguisher Safety Pin Restraining Device / May be missing or inoperative.
NOTE:Safety pin must be intact and fire extinguisher fully serviceable.
14Cabin Handset Cradle / May be damaged or soiled provided handset is fully functional.
15Electrical Outlets / (M) May be missing or inoperative provided is secured.
MAINTENANCE PROCEDURE

Electrically isolate system from aircraft power supply.
Place an INOP placard on outlet.
Make appropriate entry in discrepancy report.

16Ventilation Grill(s) / May be damaged or soiled
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
CABIN GENERAL
17Therapeutic Oxygen Fittings / (O) May be missing or inoperative provided alternate oxygen supply is available at each affected seat(s).
OPERATIONAL PROCEDURE

Refer to applicable operating rule(s) for oxygen requirements for the intended flight.
Ensure adequate oxygen supply is available for each affected seat.
Place an INOP placard on affected equipment
Make appropriate entry in discrepancy report.

18Therapeutic O2 Mask Mounting Anchor / (O) May be missing or inoperative provided mask does not restrict access to any main cabin isle or emergency egress route.
OPERATIONAL PROCEDURE

A member of the crew shall verify the affected mask(s) do restrict access to the main cabin isle or egress route prior to taxi.
Place an INOP placard on affected mounting anchor(s).
Make appropriate entry in discrepancy report.

19Universal Precaution Kit / May be missing or inoperative and contents used.
20Braille Book / May be missing.
21Spare Life Vest Bag / May be damaged or soiled provided vest is fully serviceable.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
CABIN GENERAL
22Cabin Speakers / Background static may be audible over speaker provided speaker is functional.
23Literature Pockets
(Seatback, Bulkhead, Sidewall) / May be missing, damaged or inoperative.
24Aircraft removable Equipment
(Dry Linen Storage, Waste Containers) / May be missing or inoperative.
23Emergency Floor Light Covers / (O) May be damaged or soiled provided lights are verified to be visible.
OPERATIONAL PROCEDURE

During Interior Cabin inspection, a member of the crew shall verify the Emergency Lights are clearly visible for each affected egress route.
Make appropriate entry in discrepancy report.

CESNEF1

Nonessential Equipment and Furnishings (NEF) / Cessna Aircraft Company
Citation and Propeller Aircraft
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
GALLEY
1Coffee Maker(s) / (M) May be missing or inoperative provided coffee maker(s) are electrically isolated.
MAINTENANCE PROCEDURE

Pull and secure affected coffee maker(s) circuit breaker.
Place an INOP placard on the affected coffee maker(s).
Make appropriate entry in discrepancy report.

2Coffee/Tea Brewing Pots / May be missing or inoperative.
3Water Boiler(s) / (M) May be inoperative provided boiler(s) are electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected boiler(s) circuit breaker.
Place an INOP placard on the affected boiler(s).
Make appropriate entry in discrepancy report.

4Warmer Pad(s) / (M) May be inoperative provided warmer pad(s) are electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected warmer pad(s) circuit breaker.
Place an INOP placard on the affected warmer pad(s).
Make appropriate entry in discrepancy report.

COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
GALLEY
5Ovens, Microwaves and Controls / (M) May be inoperative provided affected equipment is electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected equipment circuit breaker(s).
Place an INOP placard on the affected equipment.
Make appropriate entry in discrepancy report.

6Waste Containers / May be missing or inoperative.
7Carriers / May be missing or inoperative.
8Plate Warmer(s) / (M) May be inoperative provided plate warmer(s) are electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected plate warmer(s) circuit breaker.
Place an INOP placard on the affected plate warmer(s).
Make appropriate entry in discrepancy report.

9Air Gaspers / May be failed ON.
10Work Lights / May be missing or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
GALLEY
11Bun Warmer(s) / (M) May be inoperative provided warmer(s) are electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected warmer(s) circuit breaker.
Place an INOP placard on the affected warmer(s).
Make appropriate entry in discrepancy report.

12Thermos Unit / May be missing or inoperative.
13 Galley Heating / (M) May be inoperative provided galley heating is electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected galley heating circuit breaker(s).
Place an INOP placard on the affected galley heaters).
Make appropriate entry in discrepancy report.

14Galley Sinks and Drains / May be inoperative provided all fluids are removed from the affected area and the associated basin is placarded “DO NOT USE”.
15Chillers / (M) May be inoperative provided chiller(s) are electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected chiller(s) circuit breaker.
Place an INOP placard on the affected chiller(s).
Make appropriate entry in discrepancy report.

COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
GALLEY
16Work Table(s) / May be missing, soiled, damaged or inoperative.
17Refrigeration System / (M) May be inoperative provided system electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected system circuit breaker(s).
Place an INOP placard on the affected system.
Make appropriate entry in discrepancy report.

18Chilled Air temperature Gauge / May be missing or inoperative.
19Mirrors / May be missing, crazed, or damaged
20Power Outlets / (M) May be inoperative provided outlet(s) are electrically isolated
MAINTENANCE PROCEDURE

Pull and secure affected outlets) circuit breaker.
Place an INOP placard on the affected outlet(s).
Make appropriate entry in discrepancy report.

21Water Spigot / May be missing or inoperative provided all liquids are drained and affected container is placarded “DO NOT USE”.

CESNEF1

Nonessential Equipment and Furnishings (NEF) / Cessna Aircraft Company
Citation and Propeller Aircraft
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
PASSENGER COMPARTMENT
ENTERTAINMENT SYSTEMS(S)
1Projection Screen(s) / May be missing, damaged or inoperative.
2Video Monitor(s) / May be missing, damaged or inoperative.
3CD/DVD/Video Cassette Player(s) / (M) May be inoperative provided system(s) are electrically isolated.
MAINTENANCE PROCEDURE

Pull and secure affected system(s) circuit breaker.
Place an INOP placard on the affected system(s).
Make appropriate entry in discrepancy report.

4Interactive Audio/Video System(s) and Controls / May be missing, damaged or inoperative.
5Headphone Jack(s) / May be missing, damaged or inoperative.

CESNEF1

During the Interior pre-flight inspection, a crew member shall ensure the affected door will not interfere with egress route.
Make appropriate entry in discrepancy report.

4Lavatory Door Privacy Stop / May be missing, damaged or inoperative.
5Vanity Mirror / May be missing, damaged or inoperative.
6Toilet Seat Cover Holder / May be missing, damaged, torn, soiled, frayed or inoperative.
7Toilet Paper Roller / May be missing, damaged or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
PASSENGER COMPARTMENT
LAVATORY
8Vanity Lights / May be missing or inoperative.
9Lights / May be missing or inoperative.
10Sink Drain Screen / May be missing, damaged or inoperative.
11Assist Handle(s) / May be missing, damaged or inoperative.
12Toilet Seat Lid / May be missing, damaged or inoperative.
13Toilet Seat / May be missing, damaged or inoperative.
14Soap Holder / May be missing, damaged or inoperative.
15Faucet Aerator / May be inoperative.
16Hot and Cold Faucet Indicators / May be missing, damaged or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
PASSENGER COMPARTMENT
LAVATORY
17Cup Holder(s) / May be missing or inoperative.
18Coat Hook(s) / May be missing, damaged or inoperative.
19Deodorizer Holder / May be missing, damaged or inoperative.
20Bio Hazard Disposal Container / (O) May be missing or inoperative provided alternate disposal procedures are developed and used.
OPERATIONAL PROCEDURE

Prior to aircraft boarding, a member of the crew shall advise all passengers regarding the status of the affected equipment.
A suitable disposable container shall be accessible to all aircraft occupants.
Placard affected waste area indicating the alternate disposal container(s).
Make appropriate entry in discrepancy report.

21Inside Door ash Tray(s) / May be missing, damaged or inoperative provided ash tray(s) are not in conflict with current AD74-08-09.
23Interior Wall Trim and/or Coverings / May be missing, damaged, torn, soiled, frayed or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
PASSENGER COMPARTMENT
LAVATORY
24Air Grill Covers / May be missing or damaged.

CESNEF1

Nonessential Equipment and Furnishings (NEF) / Cessna Aircraft Company
Citation and Propeller Aircraft
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
SERVICE BAYS
1PotableWaterServiceBay
1Hold Open Rods or Lanyards / May be missing, damaged or inoperative.
2Dust Cover for Service Ports / May be missing, damaged or inoperative.
3Water Quantity Indication / May be damaged or inoperative.
4Dust Cap Chains or Lanyards / May be missing, damaged or inoperative.
2ToiletServiceBay
1Hold Open Rods or Lanyards / May be missing, damaged or inoperative.
2Dust Cover for Service Ports / May be missing, damaged or inoperative.
3Dust Cap Chains or Lanyards / May be missing, damaged or inoperative.
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
SERVICE BAYS
3Hydraulic ServiceBay
1Hold Open Rods or Lanyards / May be missing, damaged or inoperative.
2Dust Cover for Service Ports / May be missing, damaged or inoperative.
3Dust Cap Chains or Lanyards / May be missing, damaged or inoperative.

CESNEF1

Nonessential Equipment and Furnishings (NEF) / Cessna Aircraft Company
Citation and Propeller Aircraft
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
BAGGAGE AND CARGO
1Air Outlets
1Trim / May be missing, damaged, torn, soiled or frayed.
2Vent Grill / May be damaged or soiled.
2Cargo Compartment
1Floor Panel(s) / May be damaged, torn, soiled or frayed.
2Anti Skid/Non Slip Paint and/or Tape / May be missing, damaged, torn, soiled or frayed.
3Profile Bar / May be missing, damaged, bent or inoperative.
4Floor Panel Screws / No more than ____ screws may be missing from single panel.
NOTE:Ensure missing screws do not create FOD in the aircraft.
5Door Panel Lanyard / May be missing or damaged.
Continued Next Page
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
BAGGAGE AND CARGO
Continued
2Cargo Compartment
6Center Floor Guide / May be missing or damaged.
7Rail Ramps / May be missing or damaged.
8Sidewall Trim / May be missing, damaged, torn, soiled, frayed or inoperative.
9Profile Strap / May be missing, damaged, torn, soiled, frayed or inoperative.
10Safety Net Storage / May be missing, damaged, torn, soiled, frayed or inoperative.
3Cargo Door(s)
1Draft Seal / May be missing, damaged, torn, soiled or frayed.
2Insulation Blanket / May be missing, damaged, torn, soiled or frayed.
Continued Next Page
COMPARTMENT AREA / 1. REPAIR CATEGORY
2. NUMBER INSTALLED
3. NUMBER REQUIRED FOR DISPATCH
4. REMARKS AND EXCEPTIONS
BAGGAGE AND CARGO
Continued
2Cargo Compartment
3Cargo Door(s)
3Safety Strap / May be missing, damaged, torn, soiled, frayed or inoperative.
4Lower Cargo Compartment
(Cargo Pod)
1Divider / May be damaged.
2Door Access Fairing / May be damaged.
3Door Seal / May be missing, damaged, torn, soiled, frayed or inoperative.

CESNEF1