07-11-11 2010 NTB & SP
12
STATE OF CALIFORNIA
DEPARTMENT OF TRANSPORTATION
NOTICE TO BIDDERS
AND
SPECIAL PROVISIONS
FOR CONSTRUCTION ON STATE HIGHWAY IN ORANGE COUNTY IN COSTA MESA, ORANGE AND ANAHEIM AT VARIOUS LOCATIONS
In District 12 On Route 55
Under
Bid book dated March 1, 2010 / Standard Specifications dated 2010Project plans approved January 19, 2010 / Standard Plans dated 2010
Identified by
Contract No. 12-0K3504
12-Ora-55-R4.6/ 17.0
Project ID 1200000341
Electronic Advertising ContractBids open Thursday, April 8, 2010 / OSD
Dated March 1, 2010
********************************************************************************************************************************
SPECIAL NOTICES
********************************************************************************************************************************
· The contract award period has been extended for this project. See section 3-1.04.
Insert Other Applicable Special Notices Here
If no special notice applies, delete the heading, "Special Notices," above and the following page break
Insert Seal Sheet Here
TABLE OF CONTENTS
NOTICE TO BIDDERS 1
COPY OF BID ITEM LIST 3
SPECIAL PROVISIONS 6
DIVISION I GENERAL PROVISIONS 8
1 GENERAL 8
2 BIDDING 12
3 CONTRACT AWARD AND EXECUTION 13
5 CONTROL OF WORK 14
8 PROSECUTION AND PROGRESS 15
DIVISION II GENERAL CONSTRUCTION 18
12 TEMPORARY TRAFFIC CONTROL 18
14 ENVIRONMENTAL STEWARDSHIP 31
15 EXISTING FACILITIES 35
DIVISION IX TRAFFIC CONTROL FACILITIES 42
86 ELECTRICAL SYSTEMS 42
DIVISION X MATERIALS 46
87 MATERIALS—GENERAL 46
REVISED STANDARD SPECIFICATIONS APPLICABLE TO THE 2010 EDITION OF THE STANDARD SPECIFICATIONS 51
STANDARD PLANS LIST
The standard plan sheets applicable to this Contract include those listed below. The applicable revised standard plans (RSP) and new standard plans (NSP) listed below are included in the project plans as standard plan sheets.
A10A / Abbreviations (Sheet 1 of 2)A10B / Abbreviations (Sheet 2 of 2)
A10C / Lines and Symbols (Sheet 1 of 3)
A10D / Lines and Symbols (Sheet 2 of 3)
A10E / Lines and Symbols (Sheet 3 of 3)
A20A / Pavement Markers and Traffic Lines, Typical Details
A20B / Pavement Markers and Traffic Lines, Typical Details
A20C / Pavement Markers and Traffic Lines, Typical Details
A20D / Pavement Markers and Traffic Lines, Typical Details
A24A / Pavement Markings - Arrows
A24B / Pavement Markings - Arrows and Symbols
A24C / Pavement Markings - Symbols and Numerals
T1A / Temporary Crash Cushion, Sand Filled (Unidirectional)
T1B / Temporary Crash Cushion, Sand Filled (Bidirectional)
T2 / Temporary Crash Cushion, Sand Filled (Shoulder Installations)
T3A / Temporary Railing (Type K)
T3B / Temporary Railing (Type K)
T10 / Traffic Control System for Lane Closure On Freeways and Expressways
T61 / Temporary Water Pollution Control Details (Temporary Drainage Inlet Protection)
T62 / Temporary Water Pollution Control Details (Temporary Drainage Inlet Protection)
T63 / Temporary Water Pollution Control Details (Temporary Drainage Inlet Protection)
T64 / Temporary Water Pollution Control Details (Temporary Drainage Inlet Protection)
B6-21 / Joint Seals (Maximum Movement Rating = 2")
RS1 / Roadside Signs, Typical Installation Details No. 1
RS2 / Roadside Signs - Wood Post, Typical Installation Details No. 2
RS4 / Roadside Signs, Typical Installation Details No. 4
Contract No. 12-0K3504
ii
NOTICE TO BIDDERS
Bids open Thursday, April 8, 2010
Dated March 1, 2010
General work description: Treat bridge decks with methacrylate and repair joint seals.
The Department will receive sealed bids for CONSTRUCTION ON STATE HIGHWAY IN ORANGE COUNTY IN COSTA MESA, ORANGE AND ANAHEIM AT VARIOUS LOCATIONS.
District-County-Route-Post Mile: 12-Ora-55-R4.6/ 17.0
Contract No. 12-0K3504
The Contractor must have either a Class A license or a combination of Class C licenses which constitutes a majority of the work.
The DVBE Contract goal is 5 percent.
For the Federal training program, the number of trainees or apprentices is 0.
Bid Type:
UP or
C+T or
LS
Bids must be on a unit price basis.
Complete the work within 45 working days.
Call Out Number
The estimated cost of the project is $320,000.
No prebid meeting is scheduled for this project.
The Department will receive bids until 2:00 p.m. on the bid open date at Department of Transportation, 3347 Michelson Drive, Suite 100, Irvine CA 92612-1692. Bids received after this time will not be accepted.
The Department will open and publicly read the bids at the above location immediately after the specified closing time.
District office addresses are provided in the Standard Specifications.
Bidders may ask the Department questions by following the bidder inquiry instructions at:
http://www.dot.ca.gov/hq/esc/oe/project_status/bid_inq.html
The Department posts responses to the questions at the district Web sites.
Questions about alleged patent ambiguity of the plans, specifications, or estimate must be asked before bid opening. After bid opening, the Department does not consider these questions as bid protests.
Submit your bid with bidder's security equal to at least 10 percent of the bid.
Under Govt Code § 14835 et seq. and 2 CA Code of Regs § 1896 et seq., the Department gives preference to certified small businesses and non–small businesses who commit to 25 percent certified small business participation.
Under Pub Cont Code § 6107, the Department gives preference to a
Prevailing wages are required on this Contract. The Director of the California Department of Industrial Relations determines the general prevailing wage rates. Obtain the wage rates at the DIR Web site, http://www.dir.ca.gov, or from the Department's Labor Compliance Office of the district in which the work is located.
The Department has made available Notices of Suspension and Proposed Debarment from the Federal Highway Administration. For a copy of the notices, go to http://www.dot.ca.gov/hq/esc/oe/contractor_info. Additional information is provided in the Excluded Parties List System at https://www.epls.gov.
Department of Transportation
EMW
COPY OF BID ITEM LIST
Item No. / Item Code / Item Description / Unit of Measure / Estimated Quantity1 / 074016 / CONSTRUCTION SITE MANAGEMENT / LS / LUMP SUM
2 / 074017 / PREPARE WATER POLLUTION CONTROL PROGRAM / LS / LUMP SUM
3 / 074038 / TEMPORARY DRAINAGE INLET PROTECTION / EA / 10
4 / 074042 / TEMPORARY CONCRETE WASHOUT (PORTABLE) / LS / LUMP SUM
5 / 120090 / CONSTRUCTION AREA SIGNS / LS / LUMP SUM
6 / 120100 / TRAFFIC CONTROL SYSTEM / LS / LUMP SUM
7 / 128650 / PORTABLE CHANGEABLE MESSAGE SIGN / LS / LUMP SUM
8 / 141103 / REMOVE YELLOW THERMOPLASTIC TRAFFIC STRIPE (HAZARDOUS WASTE) / LF / 1,770
9 / 150714 / REMOVE THERMOPLASTIC TRAFFIC STRIPE / LF / 3,880
10 / 150715 / REMOVE THERMOPLASTIC PAVEMENT MARKING / SQFT / 240
11 / 150722 / REMOVE PAVEMENT MARKER / EA / 670
12 / 153223 / REMOVE UNSOUND CONCRETE / CF / 321
13 / 153225 / PREPARE CONCRETE BRIDGE DECK SURFACE / SQFT / 125,799
14 / 190110 / LEAD COMPLIANCE PLAN / LS / LUMP SUM
15 / 511118 / CLEAN EXPANSION JOINT / LF / 962
16 / 511124 / RAPID SETTING CONCRETE (PATCH) / CF / 321
17 / 519081 / JOINT SEAL (MR 1/2") / LF / 404
18 / 519091 / JOINT SEAL (MR 1 1/2") / LF / 558
19
(F) / 540102 / TREAT BRIDGE DECK / SQFT / 125,799
20 / 540108 / FURNISH BRIDGE DECK TREATMENT MATERIAL / GAL / 1,572
Item No. / Item Code / Item Description / Unit of Measure / Estimated Quantity
21
(F) / 750501 / MISCELLANEOUS METAL (BRIDGE) / LB / 20
22 / 840504 / 4" THERMOPLASTIC TRAFFIC STRIPE / LF / 3,590
23 / 840508 / 8" THERMOPLASTIC TRAFFIC STRIPE (BROKEN 12-3) / LF / 640
24 / 840515 / THERMOPLASTIC PAVEMENT MARKING / SQFT / 240
25 / 840525 / 4" THERMOPLASTIC TRAFFIC STRIPE (BROKEN 36-12) / LF / 4,890
26 / 840656 / PAINT TRAFFIC STRIPE (2-COAT) / LF / 6,170
27 / 850101 / PAVEMENT MARKER (NON-REFLECTIVE) / EA / 410
28 / 850111 / PAVEMENT MARKER (RETROREFLECTIVE) / EA / 270
29 / 860090 / MAINTAINING EXISTING TRAFFIC MANAGEMENT SYSTEM ELEMENTS DURING CONSTRUCTION / LS / LUMP SUM
SPECIAL PROVISIONS
Page 1 of 16
USE WITH 2010 STANDARDS.
Do not include the Standard Plans List in the project plans. Division of Engineering Services, Office Engineer will add RSP and NSP sheets in the project plans, except for an AADD project, the District will add RSP and NSP sheets in the project plans. Sheet numbers are included on the Title Sheet Index under the heading, "Revised and New Standard Plans."
Instructions for editing: Click in the left margin to select Standard Plan sheets to be included (the entire row must be selected). Use "StrikeHide no initials" key to select or undo a previous selection.
Page 1 of 10
0-SP. Insert special provisions between corresponding headings and caret separations. Delete headings and carets if you do not insert special provisions between them. Do not use a reserved heading without authorization from the OCCS Chief.
Insert Standard Plan List at the top of this document.
DIVISION I GENERAL PROVISIONS
1 GENERAL
Page 1 of 4
Section 1-1.01. Use for any bid item that has a code that does not correspond to the specification section number.
Undelete applicable rows. Add rows for nonstandard items.
Add to section 1-1.01:
Bid Items and Applicable Sections /Item code / Item description / Applicable section /
070012 / PROGRESS SCHEDULE (CRITICAL PATH METHOD) / 8 /
071301 / TEMPORARY FENCE / 80 /
071302 / TEMPORARY FENCE (TYPE BW) / 80 /
071303 / TEMPORARY FENCE (TYPE WM) / 80 /
071321 / TEMPORARY FENCE (TYPE CL6) / 80 /
071324 / TEMPORARY REINFORCED SILT FENCE / 13 /
071325 / TEMPORARY FENCE (TYPE ESA) / 14 /
072006 / TEMPORARY SUPPORT / 48 /
072008 / TEMPORARY SHORING / 48 /
072009 / TEMPORARY DECK BRIDGING / 48 /
073000 / TEMPORARY CULVERT / 62 /
073004 / 12" TEMPORARY CULVERT / 62 /
073005 / 15" TEMPORARY CULVERT / 62 /
073006 / 18" TEMPORARY CULVERT / 62 /
073008 / 24" TEMPORARY CULVERT / 62 /
073010 / 30" TEMPORARY CULVERT / 62 /
073011 / 36" TEMPORARY CULVERT / 62 /
073012 / 42" TEMPORARY CULVERT / 62 /
073013 / 48" TEMPORARY CULVERT / 62 /
073014 / 54" TEMPORARY CULVERT / 62 /
073018 / 60" TEMPORARY CULVERT / 62 /
073024 / 78" TEMPORARY CULVERT / 62 /
074015 / TEMPORARY ACTIVE TREATMENT SYSTEM / 13 /
074016 / CONSTRUCTION SITE MANAGEMENT / 13 /
074017 / PREPARE WATER POLLUTION CONTROL PROGRAM / 13 /
074018 / HEALTH AND SAFETY PLAN / 14 /
074019 / PREPARE STORM WATER POLLUTION PREVENTION PLAN / 13 /
074023 / TEMPORARY EROSION CONTROL / 13 /
074025 / TEMPORARY SOIL STABILIZER / 13 /
074026 / TEMPORARY MULCH / 13 /
074027 / TEMPORARY EROSION CONTROL BLANKET / 13 /
074028 / TEMPORARY FIBER ROLL / 13 /
074029 / TEMPORARY SILT FENCE / 13 /
074030 / TEMPORARY STRAW BALE / 13 /
074031 / TEMPORARY GRAVEL BAG BERM / 13 /
074032 / TEMPORARY CONCRETE WASHOUT FACILITY / 13 /
074033 / TEMPORARY CONSTRUCTION ENTRANCE / 13 /
074034 / TEMPORARY COVER / 13 /
074035 / TEMPORARY CHECK DAM / 13 /
074036 / TEMPORARY STRAW BALE BARRIER / 13 /
074037 / MOVE-IN/MOVE-OUT (TEMPORARY EROSION CONTROL) / 13 /
074038 / TEMPORARY DRAINAGE INLET PROTECTION / 13 /
074039 / TEMPORARY HYDRAULIC MULCH (POLYMER STABILIZED FIBER MATRIX) / 13 /
074040 / TEMPORARY HYDRAULIC MULCH (BONDED FIBER MATRIX) / 13 /
074041 / STREET SWEEPING / 13 /
074042 / TEMPORARY CONCRETE WASHOUT (PORTABLE) / 13 /
074043 / TEMPORARY CONCRETE WASHOUT BIN / 13 /
074044 / TEMPORARY CONSTRUCTION ROADWAY / 13 /
074045 / TEMPORARY LARGE SEDIMENT BARRIER / 13 /
074051 / TEMPORARY HYDRAULIC MULCH / 13 /
074052 / TEMPORARY HYDRAULIC MULCH (CEMENTITIOUS BINDER) / 13 /
074053 / TEMPORARY HYDROSEED / 13 /
074054 / TEMPORARY TACKED STRAW / 13 /
074055 / TEMPORARY SOIL BINDER / 13 /
074056 / RAIN EVENT ACTION PLAN / 13 /
074057 / STORM WATER ANNUAL REPORT / 13 /
074058 / STORM WATER SAMPLING AND ANALYSIS DAY / 13 /
121140 / TEMPORARY METAL BEAM GUARD RAILING / 83 /
121150 / TEMPORARY END SECTION / 83 /
128201 / TEMPORARY DELINEATOR (CLASS 1) / 82 /
128202 / TEMPORARY DELINEATOR (CLASS 2) / 82 /
190105 / ROADWAY EXCAVATION (TYPE Z-2) (AERIALLY DEPOSITED LEAD) / 14 /
190106 / ROADWAY EXCAVATION (TYPE Z-3) (AERIALLY DEPOSITED LEAD) / 14 /
190107 / ROADWAY EXCAVATION (TYPE Y-1) (AERIALLY DEPOSITED LEAD) / 14 /
190108 / ROADWAY EXCAVATION (TYPE Y-2) (AERIALLY DEPOSITED LEAD) / 14 /
190109 / ROADWAY EXCAVATION (NATURALLY OCCURING ASBESTOS) / 14 /
190110 / LEAD COMPLIANCE PLAN / 7 /
190111 / ADL BURIAL LOCATION REPORT / 14 /
190115 / ASBESTOS COMPLIANCE PLAN (NAUTRALLY OCCURING ASBESTOS) / 14 /
190116 / DUST CONTROL PLAN (NATURALLY OCCURING ASBESTOS) / 14 /
190117 / SAMPLING AND ANALYSIS PLAN (NATURALLY OCCURING ASBESTOS) / 14 /
192009 / STRUCTURE EXCAVATION (NATURALLY OCCURING ASBESTOS) / 14 /
192053 / STRUCTURE EXCAVATION (TYPE Z-2) (AERIALLY DEPOSITED LEAD) / 14 /
192054 / STRUCTURE EXCAVATION (TYPE Z-3) (AERIALLY DEPOSITED LEAD) / 14 /
192057 / STRUCTURE EXCAVATION (TYPE Y-1) (AERIALLY DEPOSITED LEAD) / 14 /
192058 / STRUCTURE EXCAVATION (TYPE Y-2) (AERIALLY DEPOSITED LEAD) / 14 /
193114 / SAND BACKFILL / 15 /
200102 / IMPORTED TOPSOIL (CY) / 21 /
200103 / IMPORTED TOPSOIL (TON) / 21 /
202007 / DUFF / 21 /
203004 / EROSION CONTROL (DRILL SEED) (SQYD) / 21 /
203005 / EROSION CONTROL (DRILL SEED) (ACRE) / 21 /
203006 / EROSION CONTROL (DRY SEED) (SQFT) / 21 /
203007 / EROSION CONTROL (DRY SEED) (ACRE) / 21 /
203021 / FIBER ROLLS / 21 /
203023 / COMPOST SOCK / 21 /
203026 / MOVE-IN/MOVE-OUT (EROSION CONTROL) / 21 /
203027 / EROSION CONTROL (BONDED FIBER MATRIX) (SQFT) / 21 /
203028 / EROSION CONTROL (BONDED FIBER MATRIX) (ACRE) / 21 /
203029 / EROSION CONTROL (POLYMER STABILIZED FIBER MATRIX) (SQFT) / 21 /
203030 / EROSION CONTROL (POLYMER STABILIZED FIBER MATRIX) (ACRE) / 21 /
203033 / ROLLED EROSION CONTROL PRODUCT (BLANKET) / 21 /
203034 / ROLLED EROSION CONTROL PRODUCT (NETTING) / 21 /