MINWAX COMPANY -- PASTELS WOOD STAIN, SLATE BLUE, 803
======
MSDS Safety Information
======
FSC: 8010
MSDS Date: 03/16/1999
MSDS Num: CJRBC
LIIN: 00N092155
Product ID: PASTELS WOOD STAIN, SLATE BLUE, 803
MFN: 01
Responsible Party
Cage: 0K1A4
Name: MINWAX COMPANY
Address: 10 MOUNTAINWIEW ROAD
City: UPPER SADDLE RIVERNJ07458
Info Phone Number: 800-523-9299
Emergency Phone Number: 216-566-2917
ReviewInd: Y
Published: Y
======
Contractor Summary
======
Cage: 0K1A4
Name: MINWAX COMPANY
Address: 10 MOUNTAINVIEW ROAD
City: UPPER SADDLE RIVERNJ07458
Phone: 800-523-9299
======
Ingredients
======
Cas: 64742-88-7
Name: MEDIUM ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (MINERAL SPIRITS) VP: 2
Percent by Wt: 40.
------
Cas: 61789-51-3
RTECS #: QK8925000
Name: COBALT NAPHTHENATES VP: 0
Percent by Wt: .1
======
Health Hazards Data
======
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: EXPOS MAY BE BY INHAL &/OR SKIN OR EYE CONTACT,
DEPENDING ON CNDTNS OF USE. TO MINIMIZE EXPOS, FOLLOW RECOMS FOR PROPER USE,
VENT & PERSONAL PROT EQUIP. ACUTE: IRRIT OF EYES, SKIN & RESP SYSTEM.
MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREMEOVEREXP MAY RESULT IN
UNCONSCIOUSNESS & POSSIBLY DEATH. HEADACHE, DIZZINESS, NAUSEA & LOSS
OF COORD ARE INDICATIONS OF EXCESSIVE EXPOS TO VAPS OR SPRAY MISTS. REDNESS
& ITCHING OR BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN EXPOSU
RE. CHRONIC: COBALT & COBALT CMPDS ARE CLASSIFIED BY IARC AS POSSIBLY
CARCINOGENIC TO HUMANS (GROUP 2B) BASED ON EXPERIMENTAL ANIMAL DATA, (EFTS OF
OVEREXP)
Explanation Of Carcinogenicity: COBALT NAPHTHENATE: IARC MONOGRAPHS, VOL 52, PG
363, 1991:GROUP 2B.
Signs And Symptions Of Overexposure: EFTS OF OVEREXP: HOWEVER, THERE IS
INADEQUATE EVIDENCE IN HUMANS FOR ITS CARCINOGENICITY. PRLNGD OVEREXP TO
SOLVENT INGREDIENTS LISTED IN INGREDIENT SECTION MAY CAUSE ADVERSE EFFECTS TO
THE LIVER & URINARY SYSTEMS. RATS EXPOSED TO TITANIUM DIOXIDE DUST AT
250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH EXPOSURE LEVELS ARE NOT
ATTAINABLE IN THE WORKPLACE. REPORTS HAVE ASSOCIATED RPTD & PRLNGD
OVEREXP TO SOLVENTS W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated By Exposure: NONE GENERALLY RECOGNIZED.
First Aid: INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. EYES: FLUSH EYES WITH
LARGE AMOUNTS OF WA TER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGESTION: GET MEDICAL ATTENTION.
======
Handling and Disposal
======
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. VENTILATE AND REMOVE
WITH INERT ABSORBENT.
Waste Disposal Methods: WASTE FROM THIS PROD MAY BE HAZARDOUS AS DEFINED UNDER
THE RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261. WASTE MUST BE
TESTED FOR IGNITABILITY TO DETERM APPLIC EPA HAZ WASTE NUMBERS. INCIN IN
APPRVD FACILITY. DO NOT INCIN CLOSED C NTNRS. DISPOSE OF I/A/W FED, STATE
& LOCAL REGS REGARDING POLLUTION.
Handling And Storage Precautions: DOL STORAGE CATEGORY: 2. CONTENTS ARE
COMBUSTIBLE. KEEP AWAY FROM HEAT & OPEN FLAME. CONSULT NFPA CODE. USE
APPRVD BONDING & GROUNDING PROCEDURES. KEEP CNTNR CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP LABELIN G. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions: INTENTIONAL MISUSE BY DELIB CONCENTRATING &
INHALINGCONTENTS CAN BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
&SPRAY MIST. AVOID CNTCT W/SKIN & EYES. WASH HANDS AFTER USING. THIS
COATINGMAY CONTAIN MATLS CLASSIFIED AS NUISANCE PARTICULATES (LISTED "AS
DUST" ININGRED SECTION) WHICH MAY BE PRESENT (SUPDAT)
======
Fire and Explosion Hazard Information
======
Flash Point Method: TCC
Flash Point: =40.C, 104.F
Lower Limits: 1.0%
Upper Limits: 12.5%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLESS ARE
PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE
BUILD-UP & POSSIBLE AUTOIGNITION OR EXPLOSION WHE N EXPOSED TO ETREME
HEAT.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. FLAMMABILITY
CLASSIFICATION: COMBUSTIBLE, FLASH ABOVE 99 AND BELOW 200F.
======
Control Measures
======
Respiratory Protection: IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMITS BY VENT, WEAR PROPERLY FITTED ORGANIC VAPOR/PARTICULATE RESP APPRVD BY
NIOSH FOR PROT AGAINST MATLS LISTED. WHEN SANDING/ABRADING DRIED FILM, WEAR
DUST/MIST RESP APPRVD BY NIOSH FOR DUST WHICH MAY BE GENERATED FROM PROD,
UNDERLYING PAINT OR THE ABRASIVE.
Ventilation: LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO LISTED MATLS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS 1910.94, 1910.107,
1910.108.
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH AND DELUGE SHOWER (FP N).
Supplemental Safety and Health: OTHER PRECS: AT HAZ LEVELS ONLY DURING SANDING
OR ABRADING OF DRIED FILM. IF NO SPECIFIC DUSTS ARE LISTED, APPLIC LIMS FOR
NUISANCE DUSTS ARE ACGIH TLV 10 MG/M3 (TDUST), 3 MG/M3 (RESPIRABLE FRACTION),
OSHA PEL 15 MG/M3 (TDUST), 5 MG/M3 (RES PIRABLE FRACTION).
======
Physical/Chemical Properties
======
Boiling Point: >100.C, 212.F
B.P. Text: 212-395F
Vapor Pres: SEE INGREDS
Vapor Density: HVR/AIR
Spec Gravity: 1.05
VOC Pounds/Gallon: 4.42
VOC Grams/Liter: 530
Evaporation Rate & Reference: SLOWER THAN ETHER
Percent Volatiles by Volume: 74
======
Reactivity Data
======
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: BY FIRE: CARBON DIOXIDE, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
======
Toxicological Information
======
======
Regulatory Information
======
Sara Title III Information: SARA 313 (40 CFR 372.65C) SUPPLIER NOTIFICATION:
COBALT COMPOUND - 0.2% BY WT; 0.1% ELEMENT.
Federal Regulatory Information: TSCA CERTIFICATION: ALL CHEMICALS IN THIS
PRODUCT ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA INVENTORY.
======
Other Information
======
Other Information: CODES: HEALTH 2, FLAMMABILITY 2, REACTIVITY 0. PRODUCT
CLASS: ALKYD STAIN. PHYSICAL DATA: PRODUCT WEIGHT: 8.74 LB/GAL; VOC
(THEORETICAL): 4.42 LB, 530 GM (LESS FEDERALLY EXEMPT SOLVENTS).
======
HAZCOM Label
======
Product ID: PASTELS WOOD STAIN, SLATE BLUE, 803
Cage: 0K1A4
Company Name: MINWAX COMPANY
Street: 10 MOUNTAINVIEW ROAD
City: UPPER SADDLE RIVERNJ
Zipcode: 07458
Health Emergency Phone: 216-566-2917
Label Required IND: Y
Date Of Label Review: 09/22/1999
Status Code: A
Origination Code: F
Chronic HazardIND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: IRRITATION OF EYES, SKIN &
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS & POSSIBLY DEATH. HEADACHE, DIZZINESS,
NAUSEA & LOSS OF COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO
VAPORS OR SPRAY MISTS. REDNESS & ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE. CHRONIC: CANCER HAZARD. CONTAINS
COBALT NAPHTHENATE WHICH IS LISTED AS AN ANIMAL LUNG CARCINOGEN (FP N). RE
PORTS HAVE ASSOCIATED REPEATED AND PROLONGED SOLVENT OVEREXPOSURE WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
======
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.